Vehicle Recalls: NHTSA Car Recall Alerts by Make, Model and Campaign

PACCAR Incorporated (PACCAR) is recalling certain 2027 Peterbilt 567, 579, 589, Kenworth T680, T880, W900, and W990 vehicles. The belt restraint webbing for the sleeper bunk was not secured properly during manufacturing. A bunk restraint with improperly secured webbing may fail to adequately restrain vehicle occupants during a crash, increasing the risk of injury.

K.Z., Inc. (K.Z.) is recalling certain 2026-2027 SportTrek Fifth Wheel recreational trailers. The charge line may not have circuit protection. An unprotected charge line can cause the wire to overheat, increasing the risk of a fire.

Volvo Car USA, LLC (Volvo Car) is recalling certain 2025-2026 EX30 and 2026 EX30CC vehicles. The head restraint cushion may detach during a crash. A detached head restraint cushion can increase the risk of injury during a crash.

Grand Design RV, LLC (Grand Design) is recalling certain 2027 Transcend travel trailers. The tire information label may state the incorrect tire size and cold inflation pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims." Referencing incorrect information can result in installing the wrong size replacement tires or underinflating the tires, increasing the risk of a crash.

Lippert is recalling certain power seating assemblies. The power cord fuse may not provide adequate circuit protection. In the event of a short circuit, inadequate protection increases the risk of a fire.

Hyundai Motor America (Genesis) is recalling certain 2015-2016 Hyundai Genesis, and 2017-2020 Genesis G80 vehicles. The front power seat motors may overheat due to a stuck power seat control switch, which can result in a fire while parked or driving. A fire increases the risk of injury.

Grand Design RV, LLC (Grand Design) is recalling certain 2026-2027 Imagine travel trailers. The installed safety chains are underrated for the Gross Vehicle Weight Rating (GVWR). Underrated chains can allow the trailer to detach from the tow vehicle, increasing the risk of a crash.

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2025 Allegro Bus, and Phaeton motorhomes, equipped with certain L9 diesel engines, part number D563027BX03. The remote fuel filter hoses may separate from the fitting, causing a fuel leak and an engine stall. A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall increases the risk of a crash.

Honda (American Honda Motor Co.) is recalling certain 2023-2026 CR-V Hybrid, Accord Hybrid, and 2025 CR-V Fuel Cell EV vehicles that were previously remedied under NHTSA recall number 26V366. When using the tire repair kit, pressure may build within the sealant bottle, causing the bottle cap to detach. A detached bottle cap can become a projectile and strike the user or others nearby, increasing the risk of injury.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022-2025 Freightliner Business Class M2, 2022-2027 FCCC XCM, FCCC XCR, 2023 Freightliner 108SD, 2024-2027 FCCC XCS and FCCC XBS vehicles equipped with certain Cummins L9 diesel engines. The remote fuel filter hoses may separate from the fitting, causing a fuel leak and an engine stall. A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall increases the risk of a crash.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2026 RAV4 Plug-In Hybrid vehicles. The motor generator ECU may encounter an error, causing the plug-in-hybrid system to reduce power or shutdown when driven at higher speeds. An unexpected powertrain shutdown can cause a loss of drive power, increasing the risk of a crash.

E-One Incorporated (E-One) is recalling certain 2024-2026 Typhoon N, 2025-2026 Cyclone N, and 2026 Cyclone II fire trucks. The positive power supply may be loose, causing the wiring harness and busbar to overheat. An overheated busbar can increase the risk of a fire.

Greenpower Motor Company Inc. (Greenpower) is recalling certain 2021 Nano Beast school buses. A control module interlock software error may allow the bus to move while the wheelchair lift is deployed. The bus moving while the wheelchair lift is in use increases the risk of injury.

Forest River, Inc. (Forest River) is recalling certain 2026-2027 Sunseeker, Solera, and Forester recreational vehicles. The Federal Placard may have incorrect tire inflation listed. A tire can be overinflated after referencing the incorrect information, increasing the risk of a crash.

Forest River, Inc. (Forest River) is recalling certain 2027 Surveyor recreational trailers. The exterior receptacle may not be wired to a GFCI circuit. An outlet without GFCI protection may fail to shut off electrical power when a ground-fault occurs, increasing the risk of injury.

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022-2025 S 500 4MATIC, Maybach S 580 4MATIC, Maybach S 680 4MATIC, S 580 4MATIC, 2023-2025 S 580 E 4MATIC, and 2024-2025 AMG S 63 E Performance vehicles. The front brake hoses may rupture and leak brake fluid. A brake fluid leak can extend the distance needed to stop the vehicle, increasing the risk of a crash.

Mercedes-Benz is recalling certain 2027 CLA 220 vehicles. A component of the left front seat belt may have been installed incorrectly. A seat belt with an incorrectly installed component may fail to properly restrain occupants, increasing the risk of injury during a crash.

Altec Industries, Inc. (Altec) is recalling certain 2020-2026 AA Series Aerial Device, 2021-2026 AN Series Aerial Device, 2023-2026 AM Series Aerial Device, and 2024-2026 Digger Derrick, and 2024-2025 A-Class vehicles. The turntable mounted platform access step may have been improperly welded between the step tube and mounting plate, and allow the step to separate from the vehicle. A step that separates or becomes unstable while in use, increases the risk of a fall or injury.

Ring Power Corporation (Ring Power) is recalling certain 2020 Terex General 65, 2020-2021 C6000, 2020-2022 C4000, and TC55 vehicles. The incorrect pintle hitch may have been installed without reinforced bracing, resulting in the rear bumper hitch plate bending. The pintle hitch may fail, causing a loss of trailer control and increasing the risk of a crash.

Rosenbauer America (Rosenbauer) is recalling certain 2024-2025 Commander and 2024 Warrior fire engines. The rim weld may crack, causing the wheel to separate and tire to deflate. Wheel and/or tire failure increases the risk of a crash.

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2024, 2026 Vision and All American Electric school buses. The high voltage battery system mounting bolts may be loose or missing. A high voltage battery with loose or missing mounting bolts can cause a loss of drive power, increasing the risk of a crash.

Blue Bird Body Company (Blue Bird) is recalling certain 2022-2024 All American Electric transit buses. The high voltage battery system mounting bolts may be loose or missing. A high voltage battery with loose or missing mounting bolts can cause a loss of drive power, increasing the risk of a crash.

Roadmaster Inc. (Roadmaster) is recalling certain Blackhawk All Terrain, Falcon 2, Falcon All Terrain, Falcon 3HD, Liberty, Sterling, and Nighthawk tow bars. The roll pin that secures the T-bolt to the stinger may loosen, causing the tow bar t0 separate from the hitch receiver. A separated tow bar can result in the tow vehicle detaching, increases the risk of a crash.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2027 Thomas Built SAF-T-LINER C2 and Thomas Built SAF-T-LINER C2 Jouley school buses. A software error may cause the low beam headlights to illuminate improperly. Insufficient low beam headlight illumination can reduce driver visibility, increasing the risk of a crash.

Honda (American Honda Motor Co.) is recalling certain 2023-2025 VT1300CX and 2024-2025 VT750 motorcycles. The fuel pump may malfunction due to a manufacturing defect. Fuel pump failure can cause an engine stall, increasing the risk of a crash.